2004 Chevrolet Express Passenger
Typical repair costs
- Battery replacement $150–$320
- Cabin air filter replacement $48–$103
- Check-engine light diagnosis $100–$200
- Engine air filter replacement $30–$75
- Front brake pads $200–$350
- Front brake pads and rotors $335–$625
National guide ranges for independent shops, before tax, typical for most cars. Prices for this exact car vary. Estimate a repair for your car →
Fuel economy
No official fuel economy figures for this model year.
Official: NRCan Fuel Consumption Ratings.
Recalls
Recalls are listed by model and year and may not apply to every vehicle. Check your VIN on the official recall site.
-
Electrical
Transport Canada 2023210 ·
On certain vehicles, an unused wiring harness for a rear HVAC blower motor, located in the left B-pillar area, could become damaged if exposed to moisture or contaminants. If this happens, the wires could short circuit. Note: This recall only affects cutaway chassis incomplete ve...
Official recall page (opens in a new tab) -
Fuel System
Transport Canada 2012265 ·
On certain vehicles equipped with a left side cargo door, and originally sold in or currently operated in areas of heavy road salt usage during winter months (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador), the fuel filler pipe cou...
Official recall page (opens in a new tab) -
Seats And Restraints
Transport Canada 2008120 ·
Certain full-size passenger, cargo and cutaway vans may have front and rear seat belt buckles that will not latch or will not unlatch. There are two conditions that render the buckle inoperative after customer usage. Specifically, (1) with a damaged ejector hood, the latch tong...
Official recall page (opens in a new tab) -
Seats And Restraints
Transport Canada 2005390 ·
Certain full-size passenger, cargo and cutaway vans may have front and rear seat belt buckles that will not latch or will not unlatch. There are two conditions that render the buckle inoperative after customer usage. Specifically, (1) with a damaged ejector hood, the latch tong...
Official recall page (opens in a new tab) -
Brakes
Transport Canada 2005033 ·
On certain vehicles, the hydraulic brake booster's pressure accumulator may crack and/or separate from the Hydro-Boost assembly during normal vehicle operating conditions. If a separation occurred and the hood of the vehicle was open, fragments from the accumulator could cause i...
Official recall page (opens in a new tab) -
Other
Transport Canada 2004216 ·
On certain vehicles, the transmission shift cable may allow the transmission indicator (PRNDL) to indicate a different gear selected than the transmission is in. If this condition occurred while a vehicle is resting on an uneven surface, the vehicle could roll away after the dri...
Official recall page (opens in a new tab) -
Seats And Restraints
Transport Canada 2004138 ·
Certain vehicles do not comply with the requirements of CMVSS 209, "Seat Belt Assemblies". These vehicles may have been produced with seat belt buckle assemblies containing a latch with a brittle condition that may not withstand the force requirements of the standard. In a cras...
Official recall page (opens in a new tab) -
Brakes
Transport Canada 2004037 ·
On certain vehicles, the relief valve o-ring seal within the brake hydro-boost module could fail. If this happens during braking applications, the driver may be able to hear an engine compartment noise similar to the sound that occurs when the steering wheel is turned to a full...
Official recall page (opens in a new tab)
Show 1 U.S. recall
U.S. recalls (NHTSA) with no Transport Canada record. They may not cover vehicles sold in Canada; check your VIN.
-
Exterior lighting
NHTSA (U.S.) 09E012000 ·
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS,...
Official recall page (opens in a new tab)
Source: Transport Canada Motor Vehicle Safety Recalls Database; U.S. recalls from NHTSA.
Maintenance schedule
CarDoc doesn’t have the manufacturer schedule for this model yet. Follow the schedule in your owner’s manual.
Specs
- Body type
- Van
- Engines
- 6.0 L 8-cylinder, 5.3 L 8-cylinder, 4.3 L 6-cylinder
- Fuel
- Gas
- Transmissions
- Automatic 4-spd
- Drivetrains
- RWD, AWD