2005 Chevrolet Express Passenger
Typical repair costs
- Battery replacement $150–$320
- Cabin air filter replacement $48–$103
- Check-engine light diagnosis $100–$200
- Engine air filter replacement $30–$75
- Front brake pads $200–$350
- Front brake pads and rotors $335–$625
National guide ranges for independent shops, before tax, typical for most cars. Prices for this exact car vary. Estimate a repair for your car →
Fuel economy
No official fuel economy figures for this model year.
Official: NRCan Fuel Consumption Ratings.
Recalls
Recalls are listed by model and year and may not apply to every vehicle. Check your VIN on the official recall site.
-
Electrical
Transport Canada 2023210 ·
On certain vehicles, an unused wiring harness for a rear HVAC blower motor, located in the left B-pillar area, could become damaged if exposed to moisture or contaminants. If this happens, the wires could short circuit. Note: This recall only affects cutaway chassis incomplete ve...
Official recall page (opens in a new tab) -
Seats And Restraints
Transport Canada 2008120 ·
Certain full-size passenger, cargo and cutaway vans may have front and rear seat belt buckles that will not latch or will not unlatch. There are two conditions that render the buckle inoperative after customer usage. Specifically, (1) with a damaged ejector hood, the latch tong...
Official recall page (opens in a new tab) -
Seats And Restraints
Transport Canada 2005390 ·
Certain full-size passenger, cargo and cutaway vans may have front and rear seat belt buckles that will not latch or will not unlatch. There are two conditions that render the buckle inoperative after customer usage. Specifically, (1) with a damaged ejector hood, the latch tong...
Official recall page (opens in a new tab) -
Brakes
Transport Canada 2005033 ·
On certain vehicles, the hydraulic brake booster's pressure accumulator may crack and/or separate from the Hydro-Boost assembly during normal vehicle operating conditions. If a separation occurred and the hood of the vehicle was open, fragments from the accumulator could cause i...
Official recall page (opens in a new tab)
Show 7 U.S. recalls
U.S. recalls (NHTSA) with no Transport Canada record. They may not cover vehicles sold in Canada; check your VIN.
-
Equipment adaptive/mobility
NHTSA (U.S.) 09V307000 ·
CUSTOMIZERS IS RECALLING 3 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES," THE ANTI-STOW INTERLOCK MAY NOT DETECT THE...
Official recall page (opens in a new tab) -
Equipment adaptive/mobility
NHTSA (U.S.) 09V270000 ·
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICL...
Official recall page (opens in a new tab) -
Equipment adaptive/mobility
NHTSA (U.S.) 09V272000 ·
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICL...
Official recall page (opens in a new tab) -
Exterior lighting
NHTSA (U.S.) 09E012000 ·
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS,...
Official recall page (opens in a new tab) -
Equipment adaptive/mobility
NHTSA (U.S.) 09V050000 ·
MOBILITY IS RECALLING 43 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICL...
Official recall page (opens in a new tab) -
Equipment adaptive/mobility
NHTSA (U.S.) 09V049000 ·
MOBILITY IS RECALLING 86 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VAN EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES....
Official recall page (opens in a new tab) -
Exterior lighting
NHTSA (U.S.) 05V530000 ·
CERTAIN CONVERSION VANS BUILT ON GMC/CHEVROLET CHASSIS FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT." THE HOUSING LENS OF THE CENTER HIGH MOUNTED STOP LAMP DOES NOT ALLOW ENOUGH LIGHT TO EMI...
Official recall page (opens in a new tab)
Source: Transport Canada Motor Vehicle Safety Recalls Database; U.S. recalls from NHTSA.
Maintenance schedule
CarDoc doesn’t have the manufacturer schedule for this model yet. Follow the schedule in your owner’s manual.
Specs
- Body type
- Van
- Engines
- 5.3 L 8-cylinder, 4.3 L 6-cylinder
- Fuel
- Gas
- Transmissions
- Automatic 4-spd
- Drivetrains
- AWD, RWD